How to Unclog Vape Carts Like an Expert

When you reach for your favorite vape, try to take a puff, and realize it’s not working, this can be a disappointing experience for sure. While a lot of people assume that a clogged vape cart is dead in the water and will just have to be assumed as a loss, in most cases, that’s not the case. With a little insight into what leads to a vape cart clogged or dysfunctional, you can have your vape back to good in no time and use it until the cartridge is spent. Check out some tips on how to unclog vape cart blockages and how to prevent them below.

Shop Vapes

How do vape carts get clogged?

Vape carts clog for a variety of reasons. In general, you can face three unique culprits: cold storage temperatures, improper storage practices, or a faulty vape.

If you have a vape cart made with something like live rosin, dealing with a clogged vape cart due to the cold is common. Any concentrate that has higher terpene and moisture content is vulnerable to colder temperatures. The oil can become less viscous, which will prevent the flow of the oil to the coil where it is normally heated and transformed into vape.

Vapes should also be stored upright instead of laid flat for long periods. Upright storage keeps the vape flowing toward the coil, which means you are less likely to deal with a clog due to dried-up concentrate blocking the flow of oil.

In rarer cases, the vape cart itself can be to blame. Vape carts made with low-quality components or concentrate may be more vulnerable to getting clogged. Therefore, it is always important to shop for high-quality vapes from a well-respected brand.

How to Unclog Vape Cart Blockages in Simple Steps

Step 1: Warm It Up

Cold temps can thicken your vape oil, so warming it is a great first move. The hair dryer method works well—set it to low heat and gently blow warm air over the cart for 20–30 seconds. You can also hold it in your hands or tuck it in a pocket for a few minutes. The goal is to loosen the oil so it flows toward the coil again.

Step 2: Tap and Shake

If warming doesn’t fully do the trick, give the cart a light tap on a hard surface or a gentle shake. This can dislodge any stubborn concentrate stuck in the airway or near the coil. Don’t go too hard—just a few taps should help get things moving without damaging the cart.

Step 3: Test and Store Smart

After warming and tapping, attach the cart to your battery and take a slow pull. If it’s still clogged, repeat the steps. Once it’s working, store it upright at room temp to avoid future issues. High-quality carts from trusted brands, like MAC vapes in MA, benefit from this care and clog less often.

Shop for the Highest-Quality Vape Carts at MAC

If you’re looking for high-quality vapes, be sure to stop in and see us at MAC in Chicopee or Amherst. Our menu is filled with vape carts made from the highest-quality concentrates from the most trusted brands in the state.

Shop Vapes

By Mass Alternative Care